Menu
Tablet menu

Запчасти и ремонт Ford

Характеристики двигателей Ford > Спецификации ДВС 2.5 TCI 115 л.с. Форд Транзит 1994

Характеристики двигателя 2.5 TCI (115 л.с.) Diesel Ford Transit 1994

General Specifications Transit 1995 (08/1994-07/2000)

 

 

Specifications
Engine Data
General
Identification code, LDT (light commercial vehicles) 4ED
Emission standard 97 EEC
Injection sequence (cylinders numbered from front to rear) 1‐2‐4‐3
Bore 93,67 mm
Stroke 90,54 mm
Cubic capacity 2496 cc
Compression ratio 18,0 : 1
Power output (EEC) 85 kW
Power output (EEC) 115 PS
at rev/min 4000
Torque (EEC) 256 Nm
at rev/min 2100
Idle speed rev/min 850 ± 25
Highest permissible engine speed ‐ duration rev/min 4000
Permissible engine speed ‐ short‐period rev/min 4400
Dimensions
Note
Dimensions: refer to General Specifications ‐ 2.5 Turbocharged Diesel Engine (85 PS)
Lubricants, Adhesives, Coolants and Sealers
Description Ford Specification
Grease for input shaft splines and sliding face of clutch release bearing on guide sleeve ESDM‐1C220‐A
Grease for timing belt tensioner mounting face SM1C‐4515‐A
Thread‐locking compound ‐ Loctite 270 SDM‐4G‐9107‐A
Sealer ‐ non‐hardening ‐ Hylomar PL32M SPM‐4G‐9112‐F
Super‐Plus 4 Coolant Concentrate ESD‐M97B‐49‐A
Capacity
Description Litres
Engine oil ‐ initial fill incl. filter 7
Engine oil, oil change excl. filter 5,75
Engine oil ‐ oil change incl. filter change 6
Coolant 11,6
Engine oil
Viscosity/Ambient temperature Designation Specification
Recommended engine oil:
SAE 10W30 / ‐20 to over 40 degrees Centigrade Ford Super Multigrade Engine Oil ACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SH/CD EC
Alternative engine oils:
SAE 5W40 / ‐20 to over 40 degrees Centigrade Ford Formula S Synthetic Engine Oil ACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 10W40 / ‐20 to over 40 degrees Centigrade Ford XR+ High‐performance High‐lubricity Engine Oil ACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 15W40 / ‐15 to over 40 degrees Centigrade Ford Super Multigrade Engine Oil ACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SG/CD
SAE 5W30 / ‐20 to over 10 degrees Centigrade Ford Formula E Economy Engine Oil ACEA A1‐96/B1‐96 and WSS‐M2C912‐A1

 

NOTE:

The engine oil to specification SAE 5W30 has only been approved for use in northern European territories.
If engine oils with these specifications are not available, use only engine oils which conform to specifications API SH/CD EC and CCMC PD2 or better.
Torques
General Nm lbf.ft
Support brace to crossmember 11 8
Radiator grille 11 8
Torques
Exhaust system Nm lbf.ft
Exhaust manifold to cylinder head 47 35
Front exhaust pipe to exhaust manifold 50 37
Front exhaust pipe to rear exhaust pipe 38 28
Bracket of front exhaust pipe 24 18
Exhaust manifold bracket with fuel pump heat shield 23 17
Torques
Power steering pump Nm lbf.ft
Clamp bolt 23 17
Mounting bolt 23 17
Torques
Steering Nm lbf.ft
Clamp bolt of steering intermediate shaft 30 22
Steering gear to crossmember 50 37
Torques
Exhaust gas recirculation Nm lbf.ft
EGR cooler 23 17
EGR pipe to exhaust manifold 23 17
Torques
Engine mountings Nm lbf.ft
Engine mounting bracket to cylinder block 55 41
Engine mounting bracket to transmission 62 46
Engine mounting nuts 50 37
Torques
Fuel System Nm lbf.ft
Fuel filter 17 13
Fuel injection pipes 19 14
Torques
Transmission and driveshaft Nm lbf.ft
Driveshaft centre bearing to floor assembly 33 24
Driveshaft to transmission 84 62
Gear lever to transmission housing 25 18
Transmission to engine 35 26
Fuel line bracket to transmission flange 35 26
Clutch housing front cover 25 18
Clutch housing adaptor plate 10 7
Transmission to rear transmission mounting 84 62
Bolt/nut of rear transmission mounting to transmission crossmember 84 62
Starter motor to transmission flange 35 26
Torques
Cylinder block Nm lbf.ft
Cylinder head to cylinder block ‐ Stage 1 70 52
Cylinder head to cylinder block ‐ Stage 2 70 52
Cylinder head to cylinder block ‐ Stage 3 90° 90°
Timing belt cover to adaptor plate 7 5
Torques
Cylinder head Nm lbf.ft
Cylinder head cover ‐ Stage 1 7 5
Cylinder head cover ‐ Stage 2 7 5
Rocker shaft bearing pedestal bolts, M8 29 21
Rocker shaft bearing pedestal bolts, M10 66 49
Rocker arm adjusting bolt, min. 12 9
Rocker arm adjusting bolt, max. 48 35
Bolt ‐ injector retaining plate 40 30
Thermostat housing 23 17
Temperature gauge sender unit 15 11
Engine lifting eye 23 17
Bracket for supporting engine lifting bracket 23 17

 

Случайные материалы:

Обращаем ваше внимание на то, что данный интернет-сайт носит исключительно информационный характер и ни при каких условиях не является публичной офертой, определяемой положениями Статьи 437 (2) Гражданского кодекса РФ. Все ремонтные процедуры, описанные на данном сайте должны выполнять профессионалы в авторизированном сервисе.