Menu
Tablet menu

Запчасти и ремонт Ford

Характеристики двигателей Ford > Спецификации ДВС 2.5 Форд Транзит 1994

Характеристики двигателя 2.5 Diesel (76 л.с.) Ford Transit 1994

General Specifications Transit 1995 (08/1994-07/2000)

 

 

Specifications
Engine data
General
Identification code '95 model year 4HB
Identification code '97 model year 4HC
Emission standard: 4HB 95/97 EEC
Emission standard: 4HC 97 EEC
Injection sequence (cylinders numbered from front to rear) 1‐2‐4‐3
Bore 93,67 mm
Stroke 90,54 mm
Cubic capacity 2496 cc
Compression ratio 20.8 : 1
Power output (EEC) 56 kW
Power output (EEC) 76 (PS)
at rev/min 4000
Torque (EEC) 168 Nm
at rev/min 2500
Idle speed 850 ± 25
Max. permissible engine speed Continuous rev/min 4000
Intermittent rev/min 4400
Location of engine code on cylinder block
Код двигателя 2.5 76 л.с. Форд Транзит 1994
  • 1. Engine code
  • 2.5 diesel engine (76 PS): 4HB
  • 2. Engine serial number
Dimensions
Note:
Dimensions: refer to General Specifications ‐ Turbocharged Diesel Engine 85 PS
Lubricants, Adhesives, Coolants and Sealers
Description Ford Specification
High‐temperature grease for input shaft splines and for sliding surface of clutch release bearing on guide sleeve ESD‐M1C220‐A
Grease for mounting surface of timing belt tensioner SM1C‐4515‐A
Thread‐locking compound ‐ Loctite 2706 SDM‐4G‐9107‐A
Super‐Plus 4 Coolant Concentrate ESD‐M97B‐49‐A
Sealer, non‐hardening ‐ Hylomar PL32M SPM‐4G‐9112‐F
Capacity
Description Litres
Engine Oil ‐ Initial fill incl. filter 7
Engine oil ‐ oil change without filter change 5,7
Engine Oil ‐ Oil change incl. filter change 6
Coolant 11,5
Engine oil
Viscosities/Ambient Temperature Designation Specification
Recommended engine oil:
SAE 10W30 / ‐20 to over 40 degrees Centigrade Ford Super Multigrade Engine Oil ACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SH/CD EC
Alternative engine oils:
SAE 5W40 / ‐20 to over 40 degrees Centigrade Ford Formula S Synthetic Engine Oil ACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 10W40 / ‐20 to over 40 degrees Centigrade Ford XR+ High Performance‐High Lubricity Engine Oil ACEA A3‐96/B3‐96 or API/SH/CD EC
SAE 15W40 / ‐15 to over 40 degrees Centigrade Ford Super Multigrade Engine Oil ACEA A2‐96/B2‐96 or A3‐96/B3‐96 or API/SG/CD
SAE 5W30 / ‐20 to over 10 degrees Centigrade Ford Formula E Economy Engine Oil ACEA A1‐96/B1‐96 and WSS‐M2C912‐A1

 

NOTE:

Use of engine oil with the specification SAE 5W30 is only permitted in north European countries.
If engine oils with these specifications are not available, only oils which conform to or exceed the API SH/CD EC and CCMC PD2 specifications may be used.
Torques
General Nm lbf.ft
Bracket of front exhaust pipe 24 18
Hood lock panel with radiator 11 8
Support brace to crossmember 11 8
Radiator grille 11 8
Torques
Inlet manifold Nm lbf.ft
Plenum chamber halves 23 17
Inlet manifold bracket to exhaust manifold 23 17
Inlet manifold to cylinder head 23 17
Torques
Exhaust manifold Nm lbf.ft
Exhaust manifold to cylinder head 48 36
Threaded studs of exhaust manifold 23 17
Front exhaust pipe to exhaust manifold 40 30
Bracket of front exhaust pipe 24 18
Torques
Alternator Nm lbf.ft
Drive belt tensioning strap 24 18
Alternator mounting bolt 24 18
Alternator bracket 19 14
Alternator clamp bolt 24 18
Torques
Transmission and driveshaft Nm lbf.ft
Driveshaft centre bearing to floor assembly 33 24
Driveshaft to transmission 84 62
Shift lever to transmission housing 25 19
Transmission to engine 35 26
Fuel line bracket to transmission flange 35 26
Clutch housing front cover 25 19
Clutch housing adaptor plate 10 7
Transmission to rear transmission mounting 84 62
Bolt/nut of rear transmission mounting to transmission crossmember 84 62
Nut of rear transmission mounting to transmission 50 37
Starter motor to transmission flange 35 26
Starter motor ground cable to transmission flange 35 26
Torques
Coolant circuit Nm lbf.ft
Water pump pulley 10 7
Fan pulley 10 7
Coolant hose bracket 23 17
Coolant drain plug 23 17
Temperature gauge sender unit 15 11
Engine coolant temperature sensor (ECT sensor) 13 10
Torques
Steering Nm lbf.ft
Clamp bolt of steering intermediate shaft 30 22
Steering gear to crossmember 50 37
Power steering pump mounting bolt 23 17
V‐belt clamp bolt 23 17
Torques
Oil circuit Nm lbf.ft
Oil pressure switch 14 10
Oil pressure regulating valve 56 41
Oil intake pipe to cylinder block 18 13
Oil pump to adaptor plate 19 14
Oil pump housing to cylinder block 19 14
Oil pump housing retaining plate 23 17
Oil drain plug 24 18
Sump to cylinder block 14 10
Oil cooler 70 52
Vacuum pump oil pressure pipe 21 15
Torques
Exhaust gas recirculation (EGR) Nm lbf.ft
Plenum chamber halves 23 17
EGR pipe to exhaust manifold 23 17
Torques
Engine mountings Nm lbf.ft
Engine mounting bracket to cylinder block 55 41
Engine mounting bracket to transmission 62 46
Engine mounting nuts 50 37
Torques
Fuel system Nm lbf.ft
Fuel pump to cylinder block 23 17
Fuel pump heat shield 23 17
Fuel injection pump to adaptor plate 23 17
Fuel injection pump rear bracket 23 17
Fuel line to fuel injection pump 18 13
Fuel filter 17 12
Fuel injection pump timing belt pulley 25 19
Fuel injection pipes 19 14
Torques
Cylinder block Nm lbf.ft
Camshaft rear cover to cylinder block 23 17
Front pressure plate/bracket to cylinder block 23 17
Cylinder head to cylinder block ‐ Stage 1 70 52
Cylinder head to cylinder block ‐ Stage 2 70 52
Cylinder head to cylinder block ‐ Stage 3 90° 90°
Engine adaptor plate to cylinder block ‐ bolts 1 ‐ 8 36 27
Engine adaptor plate to cylinder block ‐ bolt 9 23 17
Starter motor to cylinder block 35 26
Crankshaft rear oil seal housing to cylinder block 19 14
Allen screws ‐ rear oil seal housing 14 10
Camshaft timing pulley ‐ 1st stage 10 7
Camshaft timing pulley ‐ 2nd stage 160 118
Big‐end bearing caps ‐ Stage 1 56 41
Big‐end bearing caps ‐ Stage 2 69 51
Crankshaft main bearing caps ‐ Stage 1 84 62
Crankshaft main bearing caps ‐ Stage 2 120 89
Bolt of crankshaft pulley/vibration damper 163 12
Flywheel to crankshaft ‐ Stage 1 21 15
Flywheel to crankshaft ‐ Stage 2 30° 30°
Timing belt cover to adaptor plate 7 5
Splash shield to timing belt cover 1 0,7
Timing belt tensioner clamp bolt 24 18
Tensioning pulley bolt 58 43
Water pump to adaptor plate ‐ M8 23 17
Water pump to adaptor plate ‐ M10 46 34
Timing case cover to adaptor plate 23 17
Engine adaptor plate bracket (bolts) 46 34
Engine adaptor plate bracket (bolt and nut) 23 17
Clutch pressure plate to flywheel 30 22
Drive belt tensioning strap 24 18
Flywheel immobilising tool to cylinder block 35 26
Torques
Cylinder head Nm lbf.ft
Cylinder head cover ‐ Stage 1 7 5
Cylinder head cover ‐ Stage 2 7 5
Rocker shaft bearing pedestal bolts, M8 29 21
Rocker shaft bearing pedestal bolts, M10 66 49
Rocker arm adjusting bolt, min. 12 9
Rocker arm adjusting bolt, max. 48 36
Bolt for injector retaining plate 40 29
Thermostat housing to cylinder head 23 17
Thermostat housing bolts 23 17
EGR valve to throttle housing 18 13
Bypass hose to cylinder head 18 13
Engine lifting eye 23 17
Bracket for holding the engine lifting fixture 23 17

 

Случайные материалы:

Обращаем ваше внимание на то, что данный интернет-сайт носит исключительно информационный характер и ни при каких условиях не является публичной офертой, определяемой положениями Статьи 437 (2) Гражданского кодекса РФ. Все ремонтные процедуры, описанные на данном сайте должны выполнять профессионалы в авторизированном сервисе.